electric steam boilers
For heating the washing apparatus, although electric heating steam boiler is more convenient to use, but the cost is relatively high, so the cost will increase a lot, it is more economical method is to use gas steam boiler.
How to prevent running back pass secondary combustion 1, 30% of the rated boiler to deal with the amount of purge air before boiler ignition; the boiler must be 30% of rated air flow purge less than 5 minutes after the boiler fire, or allowed to boiler re-ignition. 2, fine-tuning the boiler and combustion systems pulverizing system operating conditions, to prevent incomplete combustion of oil and coal accumulating on the tail heating surface or flue. 3, boiler burning oil, adjust the proper air flow, fuel flow, confirming good gun oil spray, burning completely. If you find a bad oil spray gun should be discontinued immediately, and clean up. 4, when the oil application group administered powder, cast powder should be confirmed before the oil burner ignition good, or allowed to cast powder. 5, the oil powder boiler during cofiring, and check the fuel oil gun system of fire reinforcement. 6, normal operation, operation personnel in monitoring the economizer, an air preheater flue tobacco in different conditions of temperature, abnormal, should be checked to detect a fire-place. 7, air preheater sootblowing steam system normally put into operation, the soot-blowing pressure and temperature in a predetermined range. When the unit load or less prolonged 300MW kerosene mixed combustion, air preheater sootblowing steam to be continuous. 8, the air preheater into a reliable fire alarm device. 9, an air preheater inlet and outlet fume / air damper, and should be able to put an electric shutter can be open, closed tight. 10, if found preheater stall, should be put into operation again immediately, if not turn back, they should be isolated.
Hot water boilers are classified according to what conditions according to different hot water boiler fuel can be divided into electric water boilers, hot water boiler fuel, gas hot water boiler, coal-fired hot water boiler; can be divided according to whether atmospheric pressure and two kinds of hot water boiler pressure hot water boilers, hot water boilers we usually call refers to the atmospheric pressure hot water boiler, due to its safe operation, people bathing or heating largely adopted this pressure hot water boiler. 1, the tubular assembly Computerized water boiler controller, all the functions are stored on a smart chip, intelligent, digital boiler, automatic, user-friendly, intelligent control of boiler water, water reaches the automatic stop heating; large-screen font temperature, boiler water temperature at a glance. 2, boiler water temperature can be freely set from 10 deg.] C to 100 deg.] C, the boiler can supply both hot water bath can provide water for drinking, may be a dual oven. 3, the top of the furnace through the air opening is provided, the boiler is in an unpressurised state, there is no danger of explosion, while the machine is equipped with thermal protection (ultra-high-temperature furnace during the heating tube buzzer alarm and automatically stop working, secondary overheat protection (boiler housing temperature exceeds 105 deg.] C, the secondary circuit is automatically cut off), anti-dry water protection (when the furnace is less than the water level is very low, the boiler is stopped and an alarm beep), etc. .2 number of security, pot such hot water boiler drum cartridge type hot water boiler, early mostly modified from a steam boiler made, which in the case of boiler water within a boiler of natural circulation. in order to ensure safe and reliable boiler water cycle, the boiler requires to have a certain height, so such larger boiler, steel consumption, and the cost is relatively increased. However, since this type of boiler capacity and can maintain the natural water cycle, when the system pump is suddenly stopped, the pot can be effectively prevented vaporization of water. it is also for this reason natural circulation hot water boiler in our rapid development.
Shandong Zhaoyuan Mining Group Co., Ltd. is a large state-owned local asset management companies, gold mining dressing and smelting for leading industries, operates in the area of tourism, services, precious metals, real estate, eco-agriculture, with total assets of 10.2 billion yuan, Shanghai gold Exchange is an international provider of standard gold bullion. July 2017, Shandong Mining Group and fast boiler steam signed a 0.5-ton electric heating steam boiler which mainly produce steam for metallurgical mineral processing and other manufacturing processes, energy defeating small, strong ability to supply steam .
